Frymaster D50 Series Bedienungsanleitung

Price: $10.00 *8195706*Service Hotline 1-318-865-1711819-5706JUNE 2002Decathlon Series Gas Fryers (CE)Installation & Operation ManualD20, D50, D60

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the container is uprig

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General (cont.) Where conflicts exist between instructions and informa

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-3 2.4 Rating Plate This is attached to the inside right-hand corner of the fr

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) 3. Combustible construction with a minimum c

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-5 2.6 Air Supply and Ventilation (cont.) F. Adequate distance must be main

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-1 3.1 Installing the Fryer A. Initial Installation: If the fryer is installed with leg

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-2 3.3 Installing Casters and Legs A. Install casters and/or legs near where the fryer

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-3 3.4 Gas Categories Installation shall be made with a gas connector that complies w

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-4 3.5 Gas Connections DANGER Before connecting new pipe to this appliance the pipe m

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-5 3.5 Gas Connections (cont.) C. Manual shut-off valve: This gas service supplier-i

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-6 3.5 Gas Connections (cont.) H. Orifices: The fryer can be configured to operate o

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-7 3.5 Gas Connections (cont.) 4. To limit movement of the fryer, restraints independ

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-8 3.6.1 CE Specifications 3.6.1.1 Gas Types and Specifications MODEL* NOMINAL HEAT

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-9 3.6.1.2 Adjustments to Different Gas Types (cont.) NOTE: Outlet gas pressure must

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-10 3.6.2 Gas Conversion Procedures (cont.) When converting from G20 (20 mbar) to G25

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 3: INSTALLATION 3-11 3.7 Electrical Connections The fryer when installed must be electrically grounded

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 4: FRYER OPERATIONS 4-1 4.1 Initial Start-up WARNING The on-site supervisor is responsible for ensuring

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 4: FRYER OPERATIONS 4-2 4.1.1 Pilot Lighting Procedures Initial Pilot Lighting: All Dean fryers are test

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 4: FRYER OPERATIONS 4-3 4.1.2 Pilot Lighting Procedures, Electronic Ignition Systems WARNING Never use

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 4: FRYER OPERATIONS 4-4 4.2 Boil-Out Procedure (cont.) A. Pour cleaning solution into the frypot and a

DANGERThe front ledge of the fryer is not a step. Do not stand on the fryer. Serious injury can resultfrom slips or contact with the hot oil. DANGE

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 4: FRYER OPERATIONS 4-5 4.2 Boil-Out Procedure (cont.) J. Close the drain, add fresh water (without bo

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 4: FRYER OPERATIONS 4-6 4.3.1 Filling Fryer with Cooking Oil/Shortening (cont.) D. Operating Thermosta

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 5: THERMATRON OPERATION 5-1 5.1 Operating Fryers with Thermatron Controllers Many Decathlon fryers use a

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 5: THERMATRON OPERATION 5–2 5.1 Operating Fryers with Thermatron Controllers (cont.) MAIN POWER SWITCH

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 5: THERMATRON OPERATION 5–3 5.1 Operating Fryers with Thermatron Controllers (cont.) Configuration #2 M

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 6: PREVENTATIVE MAINTENANCE 6-1 6.1 General DANGER Never attempt to clean the fryer during the cooking

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 6: PREVENTATIVE MAINTENANCE 6-2 6.1.3 Periodic/Annual This appliance should be inspected and adjusted p

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-1 7.1 General DANGER Hot cooking oil/shortening will cause severe burns. Never at

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-2 7.2 Pilot Burner Malfunction (cont.) 4. Check all connections for cleanliness a

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-3 7.3 Main Burner Malfunctions (cont.) D. Fryer will not reach the temperature s

Decathlon Series Gas Fryers (CE)Installation & Operation ManualTABLE OF CONTENTS Page #1. INTRODUCTION

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-4 7.5 Wiring Diagrams 7.5.1 Decathlon D-50G and D-60G- Thermatron Controls- CE On

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-5 7.5.2 Decathlon D-50G and D-60G- Computer- CE Only 1 2 3 4 5 6 7 8 9 10 11 121

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-6 7.5.3 UFF Filtration- Typical Wiring CIRCUIT BREAKER5 AMP- 230VP/N 807-3538T3P2

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 7: TROUBLESHOOTING 7-7 7.6 Recommended Spare Parts Commonly replaced parts in older Decathlon Series ga

Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-8

Decathlon Series Gas Fryers (CE)Installation & Operation ManualTABLE OF CONTENTS (CONT.) Page #4. FRYER OPERATIONS

FINDING YOUR WAY AROUND THE DEAN DECATHLON 3” Round Drains (SCFD models)1.5” Round DrainsTop CapFlue CapBasket HangerFrypotDrain TubesDrain Valve Han

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 1: INTRODUCTION 1-1 1.1 Applicability and Validity The Dean Decathlon Series gas model family has been a

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 1: INTRODUCTION 1-2 1.4 Service Information Call the Dean Service Hotline, 1-800-551-8633, for the loca

DECATHLON SERIES GAS FRYERS (CE) CHAPTER 1: INTRODUCTION 1-3 1.6 Safety Information (cont.) WARNING boxes contain information about actions or